Contents

Operating instructions

Maintenance

• Car care
• Starting the engine - using a booster battery
• Jacking up the car
• Maintenance
• Maintenance - works
• Transmission. Main gear. Clutch
• Front axle. Steering
• Brakes. Tires. Wheels
• Wheels and tires
• Body. Salon equipment
• Electrical equipment

Engine

• General description
• Vehicle and engine identification
• Decoding vehicle identification number
• Installation of the piston in the position of the top dead center of the cylinder No. 1
• Toothed belt - removing and installing
• Cylinder head - removal and installation
• Cylinder head gasket - replacement
• Toothed belt drive
• Toothed belt - instructions for removal and installation
• Valve timing - adjustment
• Valve clearance - check and adjust
• Compression - check
• Tensioning the ribbed belt
• Ribbed belt - removing, installing and tensioning
• Engine - start
• Engine lubrication system
• Checking oil pressure
• Oil pan - removal and installation

Cooling, heating and ventilation systems

• Engine cooling system
• Radiator - frost protection
• Coolant - replacement
• Thermostat - removal and installation
• Thermal switch - check and replace
• Cooling system - leak test
• Water pump - removal and installation
• Radiator blower motor - removal and installation
• Radiator - removal and installation
• Heating and ventilation
• Air conditioner - how it works
• Deflectors - removal and installation
• Interior blower motor - removal and installation
• Additional resistor - removal and installation
• Heater / air conditioner control unit - removal and installation
• Air intake cable rods - removal, installation and adjustment
• The executive motor of the blowing air temperature regulator and the air distributor - removal and installation

Fuel injection system - gasoline engines

• General description and precautions
• Petrol injection system - general check
• Engine idle speed - check
• Engine idle speed ??- adjustment check

Power system - diesel engines

• How a diesel engine works
• Preheating device - check
• Glow plugs - removal and installation
• Preheat relay - remove, install and check
• Compressor

Fuel system

• General provisions
• Fuel system - pressure relief
• Fuel pump relay - check
• Fuel system pressure - check
• Fuel pump - check
• Fuel pump - removal and installation
• Air filter. Air intake box. Resonator - removal and installation
• Throttle control cable - adjust

Exhaust system

• Car service with catalyst
• Catalyst - principle of operation
• Exhaust turbocharger
• Exhaust system - removal and installation
• Exhaust system - leak test

Ignition system

• Ignition system
• Ignition distributor cap - check
• High voltage wires - check
• Ignition coil - check
• Ignition timing - check and adjust
• Ignition distributor - removal and installation
• Spark plugs

Clutch

• General description
• Coupling - removal, installation and inspection
• Clutch release bearing - removal, installation and inspection
• Clutch pedal - check and adjust
• Clutch actuator - bleeding

Mechanical and automatic transmissions

• General information
• Manual transmission - removal and installation

Braking system

• Specifications
• General description
• Front wheel brake pads - removal and installation
• Rear wheel brake pads - removal and installation
• Rear wheel brake pads - removal and installation
• Support plate with support. Brake disc - removal and installation
• Brake disc thickness - check
• Brake drum. Rear wheel brake pads - removal and installation
• The working brake cylinder - removal and installation
• Brake fluid
• Bleeding the brake system
• Brake hoses - removal and installation
• Vacuum brake booster - check
• Brake light switch - check, removal and installation
• Parking brake - adjustment

Suspension and steering

• Front suspension
• Suspension strut - removal and installation
• Shock strut - disassembly
• Wishbone suspension arms - removal and installation
• Front wheel hub. Rotary fist
• Intermediate shaft and axle shafts
• Intermediate shaft - removal and installation
• Front wheel drive half-shafts - removal and installation
• Drive half-shafts - check and disassembly. SHRUS covers - replacement
• Rear suspension
• Suspension strut - removal and installation
• Shock strut - disassembly
• Rear axle connecting frame
• Shock absorber - check
• Steering
• Airbag
• Hydraulic power steering
• Steering wheel airbag assembly - removal install
• Steering wheel - removal and installation
• Coil spring - removal, installation, adjustment and inspection
• Tie rod end
• Tie rod end cap protective cap
• Pleated cover
• Power steering - bleeding

Body and trim

• General description and precautions
• Front bumper - removal and installation
• Radiator grill - removal and installation
• Rear bumper - removal and installation
• Front fenders - removal and installation
• Inner wing panel (liner) - removal and installation
• Hood - removal, installation and fitting
• Trunk lid - removal and installation
• Rear hinged door - removal and installation
• Tailgate lock - removal and installation
• Tailgate spoiler - removal and installation
• Fairing - removal and installation
• Front door - removal and installation
• Door trim - removal and installation
• Door glass - removal and installation
• Manual window lifter - removal and installation
• Power window - removal and installation
• Front door lock
• Back door
• Outside rearview mirror - removal and installation
• Mirror glass - replacement
• Salon
• Center console - removal and installation
• Legroom trim - removal and installation
• Glove box - removal and installation
• Instrument panel trim - removal and installation
• Interior rearview mirror
• Rear panel trim - removal and installation
• Trunk lining - removal and installation
• Front seats - removal and installation
• Seat belt tensioner - safety measures
• Rear seat cushion, rear seat back cushion - removing and installing

Electrical system

• General description
• Additional electrical equipment - installation
• Troubleshooting electrical equipment
• Relay - check
• Turn signal interrupter - check
• Wiper motors - check
• Stop signal - check
• Heated rear window - check
• Sound signal - removal and installation
• Fuses - replacement
• Battery - removal, installation and inspection
• Generator
• Generator - removal and installation
• Generator-removal and installation
• Alternator and voltage regulator carbon brushes - check and replace
• Starter - removal and installation
• Traction relay - check, removal and installation
• Windscreen wiper
• Windscreen washer jets - adjustment
• Windscreen washer jets - removal and installation
• Windshield wiper arms - removal and installation
• Windshield wiper motor - removal and installation
• Washer reservoir. Windshield washer pump - removal and installation
• Rear window wiper arms - removing and installing
• Rear window wiper motor - removing and installing
• Washer reservoir. Rear window washer pump - removal and installation
• Wiper arm angle - check and adjust
• Lighting devices
• External light bulbs - replacement
• Replacing light bulbs
• Headlights. Front direction indicators - removal, installation, adjustment
• Rear lights - removal and installation
• Control devices
• Instrument cluster
• Control and measuring devices. Dashboard bulbs - replacement
• Steering column switches - removal and installation
• Instrument panel switches - removal and installation
• Switch for left and right power windows - removal and installation
• Radio receiver - removal and installation
• Speakers - removal and installation
• Outdoor antenna - removal and installation

Troubleshooting

• Engine
• Engine lubrication system
• Engine cooling system
• Petrol injection system
• Diesel engine power system
• Heating system
• Clutch
• Braking system
• Battery
• Generator
• Starter
• Windshield wipers

Wiring diagrams