Content

General information

• Chassis and paint codes
• Identification number locations
• Danger / warning / caution label locations
• Under-hood emission control label
• Lift and support points
• Towing
• Parts marking
• Service precautions

Specifications

• Standards and service limits
• Torque summary
• Design specifications

Maintenance

• Lubricants and fluids

Engine electrical

• Starting system
• Starter system circuit troubleshootin
• Starter
• Ignition system
• Ignition timing
• Ignition coil and spark plug
• Spark plug
• Cruise control
• Cruise control combination switch

Engine mechanical

• Engine assembly
• Cylinder head
• Engine block
• Engine lubrication
• Intake manifold and exhaust system

Engine cooling

• Cooling system
• Radiator
• Fan motor
• Thermostat
• Water pump
• Coolant
• Connecting pipe
• Drive belt
• Fan controls

Fuel and emissions

• Fuel and emissions systems
• PGM-FI system
• Electronic throttle control system
• VTEC
• Idle control system
• Fuel supply system
• Intake air system
• Catalytic converter system
• EGR system
• PCV system
• EVAP system

IMA system

• Charging system
• Auto idle stop system
• IPU cover
• Motor control module
• Motor power inverter
• IPU case
• Battery module
• Drain cover
• Idle stop switch

CVT

• A/T gear position indicator
• A/T interlock system
• Lower valve body
• Flywheel housing
• End cover
• Intermediate housing
• Input shaft
• Final drive shaft
• CVT differential

Driveline / axle

• Driveshaft
• Dynamic damper

Steering

• Steering wheel
• Steering linkage and gearbox
• Steering column
• Steering lock
• Rack guide
• Tie-rod end ball joint boot
• Gearbox mount cushion
• EPS components
• EPS motor
• Steering gearbox
• EPS control unit

Suspension

• Front suspension
• Rear suspension
• Wheel alignment
• Wheel bearing end play
• Wheel runout
• Wheel bolt
• Ball joint
• Knuckle / hub / wheel bearing
• Lower arm
• Stabilizer link
• Stabilizer bar
• Damper / spring
• Axle beam
• Dynamic damper
• Stabilizer bushing
• TPMS

Conventional brake components

• Brake pedal and brake pedal position switch/ldle
• Stop switch
• Parking brake
• Brake system bleeding
• Brake fluid level switch
• Front brake pad
• Front brake disc
• Front brake caliper
• Master cylinder
• Brake booster
• Rear drum brake
• Rear brake shoe
• Rear wheel cylinder
• Brake pedal
• Brake hose and line
• Brake hose
• Brake booster pressure monitoring system

ABS components

• ABS modulator-control unit
• Wheel speed sensor

VSA system components

• Yaw rate-lateral acceleration sensor
• VSA sensor neutral position memorization
• VSA off switch
• VSA modulator-control unit
• Wheel speed sensor

Body

• Doors
• Mirrors
• Glass
• Interior trim
• Consoles
• Dashboard
• Seats
• Bumpers
• Hood
• Hatch
• Fuel fill door
• Exterior trim
• Fenderwell
• Frame

Heating, ventilation, and air conditioning

• Climate control
• A/C service tips
• Radiator and A/C condenser fan
• A/C condenser fan high speed
• Sunlight sensor
• Power transistor
• Air mix control motor
• Mode control motor test
• Recirculation control motor
• Evaporator tamperature sensor
• A/C compressor clutch
• Receiver / dryer
• A/C compressor
• A/C line
• Blower unit
• Expansion valve
• Evaporator core
• Heater unit / core
• Air mix control
• Humidity / ln-car temperature sensor
• Outside air temperature sensor
• Sunlight sensor
• Climate control unit knob
• System evacuation
• System charging

Body electrical

• Relay and control unit locations
• Connectors and harnesses
• Fuse / relay boxes
• Power distribution
• Ground distribution
• Under-dash fuse / relay box
• 12 volt battery
• Relays
• Ignition switch
• Multiplex integrated control system
• Keyless / power door locks / security system
• Horns
• Exterior lights
• Turn signal / hazard warning lights
• Interior lights
• Dashlights
• Entry lights control system
• Power windows
• Wipers / washers
• Gauges
• Safety indicator system
• Reminder systems
• Accessory power socket
• Power mirrors
• Rear window defogger
• Immobilizer system

Audio, navigation, and telematics

• Audio system
• Navigation system
• Handsfreelink system

Restraints

• Seat belts
• Front seat belt
• Rear seat belt
• Supplemental restraint system
• SRS unit
• ODS unit
• Front passenger's weight sensor output
• Driver's seat position sensor operation
• Front passenger's airbag
• Side airbag
• Side curtain airbag
• Airbag and tensioner
• Cable reel
• SRS unit
• Side impact sensor
• Rear safing sensor
• Front passenger's weight sensor
• Front impact sensor
• Driver's seat position sensor
• Front passenger's airbag cutoff